There are 5 types of single ply roofing systems commonly used on flat roofs. They are EPDM, TPO, Modified Bitumen Cold Apply, Modified Bitumen Self-Adhering and Modified Bitumen Torch Down systems. Commercial Roof USA specializes in a 2 ply rubber roofing system which is the Modified Bitumen Torch Down membrane. The 2 ply system consists of a fiber base sheet with a self adhering modified base attached to it, which is considered the first layer. The second layer is the Modified Bitumen Torch Down membrane which includes embedded ceramic granules for protection against harmful ultraviolet light.
All single ply roofing systems come with warranties of between 15 and 20 years, however, the 2 ply rubber roofing system, we specialize in, comes with a 40 year warranty.
The video below shows the installation of a 2 ply Modified Bitumen Torch Down rubber roofing system over an existing Tar and Gravel Roof. This 2 ply system can be installed over any existing roof with minimal surface preparation.
Many commercial roofs have a number of A/C and ventilation units, cell phone antennas, skylights, chimney stacks, drainage systems and other permanent structures on them. At some point, these structures will require maintenance or replacement. The servicing activity means that there will be a lot of foot traffic throughout the life of the roof.
During these service calls, nails, screws, wires, and tools may be unintentionally dropped, and many times, even left behind. Oddly enough, seashells are often found on commercial roofs near coastlines. These sharp objects become a potential problem for a single-ply rubber roof because they are repeatedly stepped on and create many punctures, however, a two-ply rubber roof system will withstand this kind of foot traffic.
With Ceramic Granules – A Modified Bitumen Torch Down rubber membrane can have a built-in surface protection of ceramic granules. The ceramic granules protect the rubber membrane from harmful ultraviolet light.
Without Ceramic Granules – A Modified Bitumen Torch Down rubber membrane can come without the ceramic granules, however, it is necessary to apply an aluminum asphalt coating every 3 to 5 years to maintain the integrity of the rubber membrane.
Single-ply roofing systems start presenting issues within a short period of time after they have been installed. EPDM and TPO membranes are very thin and can be easily punctured with very minimal foot traffic. Also, these membranes cannot withstand direct sunlightwithout compromising the 15 year life expectancy; they become brittle. The adhesives break down and cause the seams to separate.
EPDM rubber is the same material that is used in the inner tubes of tires. It is very thin and not UV protected.
To the left is an image of a Modified Bitumen Granular rubber membrane. The ceramic granules are embedded into the surface to protect it from harmful ultraviolet light
Once the fiber base is installed, the rubber with the ceramic surface get fused or melted to the base layer with a torch. When combined, the 2-ply membrane becomes approximately 7 mm thick.
Not all roofing contractors are familiar with all types of roofing systems, therefore, they will only offer the one roofing system they are comfortable with.
It is common for construction contractors, to offer their roofing installation services, however, they do not specialize in flat roofs.
Some 30 years ago, Commercial Roof USA was one of the first roofing companies to use the Modified Bitumen Torch Down Roofing System. At first, we only installed a single-ply system. In 2005, a manufacturer developed a new product to improve the Modified Bitumen in the form of a self-stick base. After incorporating this base with the Modified Bitumen Torch Down rubber membrane, we realized that we had found the best flat roofing system, which has enabled us to provide a 40 year warranty with every roof installation.
In 2005, many manufacturing companies of roofing materials, were popping up to provide the Modified Bitumen Membranes; GAF, John Mansfield, Firestone, Polyglass, and many others. Through our experience, we have found that the Firestone APP Modified Bitumenroofing membrane has the best quality. We currently specialize in the installation and repairing of flat roofs using only roofing products from Firestone.
The 2 ply Modified Bitumen Rubber Roof Membrane is by far the toughest roofing system. It can handle extreme weather conditions and be installed over almost any surface. Regardless of where it is installed, Commercial Roof USA, provides a 40 year warranty with every roof we install.
We have been repairing leaky skylights over 30 years We have tried many types of products…
Leak Repairs on Flat Roofs This image explains about seams on a Torch Down Roof…
EPDM & Modified Bitumen Torch Down Rubber Roofs – Which is the Best? Leave a…
Sven Ferreira – Roofing Contractor Norwalk CT My Roofing Experience. My roofing experience began at…
Andre Ferreira – Roofing Contractor in Norwalk CT A little about myself. At the age…
Naas Ferreira – Roofing Contractor and Consultant I started his roofing business in 1997. Then,…
